Weber 3100 Manual do Utilizador

Serial NumberPlease use this number in registering your warrantyand any correspondence with the factory.WEBERWEBERGENESIS®3100 SeriesNatural Gas Barbe

10Step 2Assemble wheelsYou will need: axle, two wheel hubcaps, two wheels, wheelframe, hammer and a block of wood.Place one end of the axle on the blo

11Step 4Continue frame assemblyYou will need: frame assembly, wheel frame assembly,front panel, caster frame, four 1/4-20 x 1/2 inch bolts, four nylon

Step 7Install side burner locksNote: The locks are taped to the inside of the sideburner lid.You will need: frame assembly, two side burner lock and a

13Step 9Install gas supplyGeneral Specifications for PipingNote - Contact your local municipality for buildingcodes regulating outdoor gas barbecue in

14Step 10Install igniterNote - The igniter wires are already attached to the GasCatcher Ignition Chamber and the igniter. This was done tofactory test

15Step 13Install side burnerYou will need: side burner assembly, burner grate, andmanifold bracket.WARNING: Make sure gas supply is OFF.Slide the sid

16Step 15Check for gas leaksTo perform leak checks: Slide back the collar of the quickdisconnect. Push male fitting of the hose into the quickdisconne

17Check:a) Hose to manifold connection. Figure 18 (a).b) Manifold to side burner hose connection.Figure 18 (b).WARNING: If there is a leak at connec

18Step 18Install the lidYou will need: lid, two hinge pins and two hair pin cotters.Set the lid in place. Align the hinges at the rear of thebarbecue.

19Figure 25Insert in frame braceTool holders(a)(b)Control panelPhillips screws/washersStep 20Secure side burnerStand to the right side of the barbecue

2DANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manualmay result in serious bodily injury or death, or in a fir

20Slot in frame(view from below)Insert one end of the hinge rod into the hole in the frame.Figure 28 (a).Insert the other end into the hole in the swi

Step 22Complete accessory installationYou will need: work table, two accessory trays, Warm-UpBasket, warming rack, thermometer, three tubing plugs and

22LightingSummary lighting instructions are on the control panel.1623457Figure 1Crossover Ignition System1) Open the lid. Figure 1.2) Make sure all bu

23WARNING: If the burner does not light, turn the Front burner control knob to OFF and wait 5 minutes tolet the gas clear before you try again or try

24Lighting the side burnerThe side burner has a separate ignition system from themain cooking box.5241Figure 3 DANGERFailure to open lid while igniti

25CookingWARNING: Do not move the Weber Gas Barbecuewhen operating or hot.You can adjust the FRONT, CENTER and BACK burnersas desired. The control se

Cast Iron Cooking GratesWARNING: Follow all safety instructions providedwith your barbecue. Do not drop cast iron grates, theywill break. Prior to s

2727WARNING: If there is a leak at connection a,retighten the fitting with a wrench and recheck forleaks with soap and water solution.If a leak persi

2828General MaintenanceWeber Spider Stopper GuardsYour Weber Genesis Gas Barbecue, as well as anyoutdoor gas appliance, is a target for spiders and ot

2929g) Lift and twist the burner assembly slightly, to separatethe crossover tube from the burners. Figure 14.Remove the burners from the cooking box.

3Weber-Stephen Products Co. (Weber) herebywarrants to the ORIGINAL PURCHASER of thisWeber Gas Barbecue that it will be free ofdefects in material and

3030Crossover Ignition System OperationsIf the Crossover Ignition System fails to ignite the Frontburner, light the Front burner with a match. If the

3131ProblemBurners burn with a yellow or orange flame, inconjunction with the smell of gas.Burner does not light, or flame is low in HIGH position.Exp

3232ProblemSide burner does not light.Flame is low in HIGH position.Flame is very yellow in conjunction withthe smell of gas,ORBurner makes popping no

34341 Hair pin cotters (2) 2 Hinge pins (2) (Hardware size: 1/4 x 1 1/2 inchclevis pin)3 Left Endcap 4 Shroud Assembly5 Lid handle 6 Warm-Up Basket7 W

3535WEBERWEBER78910111213141517-1813,18212524495051525338484744424140393637343031323316233546452627282943381234562219205554®®®®®®®®

A FINAL WORDOFTHANKShank you for choosing a Weber Barbecue.Our family here at Weber has worked hardto produce the highest quality products for your sa

© 1998 Weber. Weber, , Genesis, Flavorizer and Crossover areregistered U.S. trademarks; Perma-Mount, Gas Catcher,FlameCheck, Steam-N-Chips, Spider

5ContentsWARNINGS... 2Warranty & Patents...

6General InstructionsYour Weber Gas Barbecue is a portable outdoor cookingappliance. With the Weber Gas Barbecue you can grill,barbecue, roast and bak

Step 1Check package contentsCooking box (assembly)Lid (assembly)HoseBottom trayWork tableTwo accessory traysSwing table7AssemblyTools neededRegular sc

Control panelFront panelLeft frameWheel frameTwo frame connectorsFive long Flavorizer BarsEight short Flavorizer BarsTwo wheelsTwo aluminum drip pansC

Two wheel hubcaps(actual size)Two hinge pins(hardware size: 1/4 x 1 1/2 inch clevis pin)(actual size)Five 1/4-20 x 2 inch bolts(actual size)Six 1/4-20